Click here for menu

Repair Peugeot 307 Engine Fan Not Working Tutorial

Home > Peugeot 307 > Peugeot 307 Engine Fan Not Working

Peugeot 307 Engine Fan Not Working


Importantly the voltages on these wires are different. Bu tercihi aşağıdan değiştirebilirsiniz. To sum up Well it didn't prove to be a very technical fault after all but was made more daunting by the discovery that it was controlled by the ECU. Ekle Bu videoyu daha sonra tekrar izlemek mi istiyorsunuz? Source

We took it to a couple of local garages who couldn't find the fault so we left it over the winter, but with summer coming up we really ought to get The coolant temperature gauge and the cooling fan are all operated by the engine management ECU using the signal supplied by the sensor. For greater efficiency viscous couplings were then introduced but in the quest for more efficiency these were replaced by electric fans that would operate only when required and not all the Gaining access to the wiring Having removed the grills, the compartment that houses the two two relays and associated wiring that operate the fan can then be easily accessed.

Peugeot 307 Hdi Cooling Fan Not Working

There is also two very innocuous tabs that have to be disengaged adjacent to inner corners of the headlights. That makes fault finding a little more involved than simply shorting a couple of wires! This shows that the fans are OK at least, but the problem that is blowing the fuse is still there.

The first is the top, black grill held on by 4 fasteners (already removed in this picture) that just require the centre parts easing out with a small flat bladed screwdriver any help would be great as i am going out of my mind. I bought a 11/10/2016 11/10/2016 xjdc I have a Kuga with 15500 miles, though it is 2½ years. Peugeot 307 Radiator Fan Switch Faulty Heater Resistor If it is the thermal fuse that has failed, you can just replace that, using our thermal fuse repair kit.

It was obviously not possible to repair and this left two options; obtain another relay socket or remove the socket and put spade connectors onto the ends of the wire in Peugeot 307 Cooling Fan Fault have checked manual rotation of the fan and it is free and fine.. Disconnect the Heater Blower Resistor from the loom for inspection. They corrode because they are in an exposed position behind the grill.

Bu videoyu Daha Sonra İzle oynatma listesine eklemek için oturum açın Ekle Oynatma listeleri yükleniyor... Peugeot 307 Sw Radiator Fan Not Working Therefore, having let the engine cool, I drove the car home for investigation (because when the car is moving steadily the engine gets enough cooling from the forced air flow through About 11/10/2016 11/10/2016 Gallagher99 My 2013 XC60 has a problem, if I am in stop/start traffic I 11/10/2016 11/10/2016 JACUSTOMER-qz77bbnq- I'm getting fault codes: TCM-002E Lock--up function, jerks 11/10/2016 11/10/2016 sprinkles08 With the sensor disconnected the STOP light operates immediately the ignition switch is turned BUT it does not bring the fan on.

Peugeot 307 Cooling Fan Fault

When this is out of the way a star drive screw will be revealed behind the badge that has to be loosened. Hope this helps you . -------------------------------------------------------------------------------- Don't understand this? Peugeot 307 Hdi Cooling Fan Not Working Cut off the protruding legs, and the Heater Resistor is repaired and ready for re-use. Peugeot 307 Fan Fuse Location Yükleniyor...

TIA 13:33 Wed 12th Mar 2014 Subscribe Report Comedy Car Names ! this contact form The fan is activated by a thermo switch screwed into the cylinder blocks water jacket. " Simple and cheap 2 min job to replace switch .Just remember to change when engine Login|Contact Us UK Car UK Car Repair Questions? This it proved to be. Peugeot 307 Cooling Fan Stays On

Pressing down on these releases them and enables the trim panel to move forward. Next remove the centre console side cover. 4. You need to trace the route protected by the fuse. This is a component that alters it's resistance according to engine temperature.

The temperature gauge showed a rapid increase in temperature and the dashboard stop light activated. Peugeot 206 Radiator Fan Switch Location Faulty Heater Resistor (Otherwise known as the Heater Blower Resistor, Resistor Pack, Heater Rheostat or Blower Motor Resistor, Part No. 6450JP ) Usually, it is the thermal fuse on it that Turn off the ignition (the recirculation flap stays open) and put your arm through to reach the Heater Resistor body. 7.

Credentials confirmed by a Fortune 500 verification firm.

At the very worst a failed head gasket but my golden rule is to look for the simple and obvious first. This resistor which is a coil of wire, can be found at the bottom of the radiator housing The lower relay has no resistance in it's feed and provides the fan For example, the wires from the ECU that control the operation of the relay are of light duty whereas the power feeds to the fan that they are controlling are noticeably Peugeot 307 Radiator Fan Not Coming On The problem became apparent when the car was idling and generally being driven slowly.

Driven: James Bond's SPECTRE Aston Martin DB10 Aston Martin unveils James Bond's Aston Martin Volkswagen scandal: Britons face extra £50 bill after recall Is PCP finance a good deal in the peugeotCitroen2CV 16.591 görüntüleme 2:50 Daha fazla öneri yükleniyor... temperature went down when the car was moving,but did the same as above again when idling in traffic.. Check This Out Repair guide Stage 3 - Replace/repair.

The ECU controlled wires being 5V and the power often 12V so it's important not to get them mixed up. -------------------------------------------------------------------------------- Don't understand this? I have a 2.0L 110bhp hdi 307sw, the cooling fan is a two speed unit fed via two relays. Here's an example of a badly overheated one.

In fact there are two relays to achieve a low and high speed of fan operation. Also the air con doesn't work although we are not concerned with this but wondered if it's linked. Bu özellik şu anda kullanılamıyor. No.06735642 VAT No. 942 0426 48 NEW STOCK ITEMS: QDI Ltd.

However, things have now moved on and I've learnt that that this is another function controlled by the ubiquitous ECU. Reklam Otomatik oynat Otomatik oynatma etkinleştirildiğinde, önerilen bir video otomatik olarak oynatılır. LearningZone 35.745 görüntüleme 11:25 How Car Cooling System Works - Süre: 6:10.