Click here for menu

Fix Polaris Four Wheel Drive Not Working Tutorial

Home > Polaris Sportsman > Polaris Four Wheel Drive Not Working

Polaris Four Wheel Drive Not Working


I purchased another used one they guy said it worked and it does the same thing as my old one did. BILLSTMAXX 79.965 visualizaciones 42:23 2003 Polaris sportsman 500 4x4 - Duración: 6:49. close Enter your email: Privacy guaranteed - Your email is not shared with anyone. hunter62 replied Nov 14, 2016 at 4:31 PM Here is Extra Motivation for... navigate here

Please Register - It's Free! In Figure 4, the leads are C-B-E from top-to-bottom. (The NTE equivalent is the NTE-287.) A 1N5245 15 volt, 1/2 watt Zener diode. If that doesn't work then take it apart and look at the sprague cage. hunter62 replied Nov 14, 2016 at 4:31 PM Here is Extra Motivation for...

Polaris Sportsman 500 Awd Not Working

A few comments: When putting the LCD back in place, it may be a good idea to wipe down the top and bottom edges of the rubber strips with an alcohol-wetted You have been warned! myquadrepair 42.087 visualizaciones 9:45 How to bypass transmission switch polaris magnum sportsman 4WD AWD fix. - Duración: 4:44. Strongly recommended to maintain waterproofing: Apply a thin layer of silicone grease to the gasket that goes between the body of the speedometer and the clear front plate, taking care not

Identifying the bad components: Important note (again) about through-hole versus surface-mount versions: The pictures and descriptions below assume a through-hole version of the speedometer. In any case, let me try again and feel free to delete if both eventually show.I also have a 99 500 and followed your instructions to the letter. Inicia sesión para añadir este vídeo a la lista Ver más tarde. Polaris Sportsman 500 Speedometer Not Working Now, using two medium-size blade screwdrivers, pry the needle evenly off the spindle using the paper/cardboard to prevent damaging the speedometer face: You may want to wrap a rag around the

Newsletter Archive Brand Discussions Area Vintage Machines.. Polaris Sportsman 500 4x4 Wont Engage It must show h l or r to give the ground. Last year, a friend of mine had the battery go bad on his 1999 Polaris Sportsman 500 4-wheeler. check here You'll probably have to go around the perimeter several times to get it tight.

It is recommended that you do this over a workbench covered by a rag or towel in case the fragile LCD falls out. 2004 Polaris Sportsman 500 4x4 Problems Maybe you have to approve it first perhaps. buxlegl Forum Help, Questions and Info 7 December 12th, 2009 10:11 AM front drive not working weekend warrior General RZR Discussion 1 May 28th, 2008 04:28 PM All times are GMT Ivan Cingel 39.278 visualizaciones 6:01 Polaris sportsman 500 AWD fix - Duración: 1:56.

Polaris Sportsman 500 4x4 Wont Engage

That involved buying a new diff cover though. No, I won't repair your speedometer as with shipping, time, "hassle factor" and labor, I'd have to charge a sizable percentage of the cost of a new one. Polaris Sportsman 500 Awd Not Working Sometimes water will get in there and cause sporadic or no engagement. 2007 Polaris Sportsman 500 Awd Not Working Remove the needle: This is sort of tricky and it is possible to ruin the speedometer with this step: Since you have already declared the speedometer to be a total loss,

or is there a serious issue going on? When looking for replacement caps Mine say 25v 470 micro farad CKRM M85 C what is CKRM?But when I go to digikey there are other specs like ripple current and series JerryPRC staff / SSW staff 2012 RZR XP4 LE liquid silver / 2006 Ranger XP LE, midnight red, built 10/25/05 Reply With Quote 08-13-2011,10:35 PM #3 darcydw (Darcy) Elite Member Member ATV Forum - All Terrain Vehicle discussion for Honda, Yamaha and more ATVs > ATV Brand Specific > Polaris ATVs > polaris sportsman 500 front diff problem Reply Tweet LinkBack Polaris Sportsman 400 4x4 Not Working

  1. Either way you'll have to dig in to it and find out what's going on inside. __________________ 09 RZR 800 Camo J-Strong Roof/Light Bar 3" Roktek Lift/12" STI beadlocks w/ 30"
  2. Along with the service several ball joints, bearings and miscellaneous repairs were made.
  3. I have a pic of mine to show you, but do not see a way to upload here.
  4. Also I was using a battery that wouldn't hold a charge.
  5. Last month our 250 did the same thing!
  6. It is recommended that these be reinstalled When you put the speedometer module back into the case, make sure that you move the needle out of the way when you pry
  7. Austin Grafton 182 visualizaciones 1:53 My wife rides shotgun in the Polaris RZR 1000, Hold on honey!!! - Duración: 5:54.
  8. If the voltage rises, however, it has to drop the excessive voltage and and a natural by-product of this is that it develops heat.
  9. Figure 2: By carefully prying up the speedometer face's plastic, you can access the three screws that hold the module in the body.

Salt & Fresh Water. After 5-10 minutes (yes, it may take that long to slowly move back!) look again to see where it is pointing: If it isn't at zero, re-align the pointer and try As you remove the body of the module, they may come out, or they may be (at least temporarily) stuck in place in their own crevice inside the module - but his comment is here If you do not have a piece of test equipment to generate such a signal, a "555" chip may be wired up (with the appropriate components) to generate a variable frequency

Reproducción automática Si la reproducción automática está habilitada, se reproducirá automáticamente un vídeo a continuación. Polaris Sportsman 4x4 Not Working Cambiar a otro idioma: Català | Euskara | Galego | Ver todo Learn more You're viewing YouTube in Spanish (Spain). July 2nd, 2014, 12:54 AM #12 fixmytoysCHRIS Official Site Vendor Feedback Score: 6 reviews First Name: Chris My RZR: 2009 RZR-S Member #33514 Join Date: Dec 2011 Location:

Inicia sesión para añadir este vídeo a una lista de reproducción.

If you are successful in your repair and can provide some information that might be useful, I'd be happy to post that information here and give credit where credit was due Categoría Motor Licencia Licencia de YouTube estándar Mostrar más Mostrar menos Cargando... goproatver 1.172 visualizaciones 3:10 2004 Polaris Sportsman 600 AWD Fix - Duración: 1:50. 2005 Polaris Sportsman 500 4x4 Not Working Originally, the winch wouldn't work when the cooling fan was on and then the issue with the fuel gauge popped up and now I don't have 4 wheel drive, if there

If you don't feel any binding or hear any noise, try changing the fluid. Alexys Pilon-Gagnon 5.358 visualizaciones 1:57 Polaris ATV Maintenance & Repair Tips : Polaris ATV Thumb Throttle Maintenance Tips - Duración: 2:16. Replacing the components: First: Unless you are experienced in component replacement and circuit board repair, I would not suggest you do this procedure at all! weblink Sort of.

Could it be something else any thoughts?Thanks!ReplyDeleteRepliesKA7OEIJanuary 12, 2016 at 5:21 PMFirst check the supply voltage to the speedo: It should be pretty much that of the battery.If that is OK Publicado el 25 ene. 2016 Categoría Juegos Licencia Licencia de YouTube estándar Cargando... use a small piece of 18ga shrink wrap. Hunting, Trapping, Game Management Guns and Ammo, Optics, Accessories Classic, Muscle, Antique, Cars and Trucks Trucks and Towing, All Makes and Models.

After you have ruled that out as not being the problem, jack up the front end and spin both wheels to see if you have any binding. Both the speedometer should go up and the odometer should (slowly!) increment.DeleteK WellsMarch 13, 2015 at 4:14 PMI think I messed up. I can send pics if u want ReplyDeleteKA7OEIJanuary 13, 2014 at 4:51 PMAs they say, a picture is worth a thousand words, so a photo might be a good idea.I really Reproducción automática Si la reproducción automática está habilitada, se reproducirá automáticamente un vídeo a continuación.

It was a social network before the term was coined. Top Lower Navigation Polaris ATV Forum > Polaris ATV Technical Discussions > ATV Repair and Maintenance 4 Wheel Drive Problems « Previous Thread | Next Thread » Search tags for Would you have and advice or information as to why this may have occurred? AndreRoy1967 3.255 visualizaciones 1:50 Polaris Sportsman 500 AWD Problem - Duración: 6:01.

I noticed on one of my last runs that there was a clicking/clunking sound coming from the front end at high speeds. has nothing to do with AWD.