Click here for menu

Fix Polaris Scrambler Radiator Fan Not Working Tutorial

Home > Polaris Sportsman > Polaris Scrambler Radiator Fan Not Working

Polaris Scrambler Radiator Fan Not Working


Arctic Cat CAN-AM (BRP) KTM Honda Kawasaki Chinese Quads Kids Quads Polaris Suzuki Yamaha SxS / UTV Discussion Arctic Cat Prowler Kawasaki Mule and Teryx Polaris Ranger and RZR Yamaha Rhino On this page in the parts list, its kinda hard to tell but I think Is Ref #11 because the connector is facing downwards. However, if all other systems are proved to be operating, then the switch becomes the prime suspect... QuadManiac is offline Quote Quick Reply Reply Page 1 of 4 1 23 Last vBulletin Message Cancel Changes Quick Reply The following errors occurred with your submission Okay this contact form

About Press Copyright Creators Advertise Developers +YouTube Terms Privacy Policy & Safety Send feedback Try something new! Transcript The interactive transcript could not be loaded. Sent from my C771 using Tapatalk 2 Are you talking about the fan breaker under the seat? you might want to double check the temp vs sensor.

Polaris Sportsman 500 Fan Not Working

PB Oil cooler. Head ported by Thumper Racing w/ new intake seats done by Pro-1 racing. I've tested the relay under the gas tank and that it is at zero. Trailers, Toy Haulers, Motorhomes.

Pre 1975, Dirt bikes, ATV's, MiniBikes, Snowmobiles, etc.... I noticed her fan was not turning on. Open element K&N filter, and precharger. Polaris Sportsman 500 Temperature Sensor Visit the new Polaris Tech Site Established Sept 2010 I do not ride with a driver that text messages while driving, say NO also and put this in your signature.

Registered Users do not see these ads, So Register, It's Free! #2 (permalink) 01-19-2010, 11:21 AM blueline15 Polaris ATV Legend Member #230 Join Date: Feb 2009 Location: Washington Polaris Sportsman 500 Fan Switch I just need to work out this cooling issue and I shoudl be good to go. **I checked the cooling fan breaker and it appeared as if it was not popped. Any suggestions are appreciated.

I will go tear into it right now. #7 (permalink) 01-19-2010, 06:22 PM blueline15 Polaris ATV Legend Member #230 Join Date: Feb 2009 Location: Washington State Posts: 6,903

Today 03:57 PM by oldskool83 8 02 660 cdi wire question Today 03:28 PM by Kevinsellards9913 0 Rear Grab Bar diameter Today 02:44 PM by cookies934 24 Top end rebuild update Polaris Parts There is also a Water Temp. I just removed the plastic panel and that bottle is almost empty. It must have been running for approximately 15 minutes.

Polaris Sportsman 500 Fan Switch

Sign in to add this video to a playlist. Also: Found out the hard way that the corroded connections in this area can cause all kinds of funky stuff to happen! Polaris Sportsman 500 Fan Not Working Note that passwords are case-sensitive. Polaris Fan Switch I've hot wired her fan to remain on and that fixed the overheating issue.

Thermo switch 2 should be tested by measuring resistance across the switch contacts - they should be open (infinite resistance) when cold, and should be closed (low resistance - say 1 If so, I already ordered a fan switch and hopefully that will get me up and running... Videos on You Tube Feedback: (1) 06-04-2012, 07:54 PM #6 Todd Edge Trail Rider Join Date: Jun 2012 Location: Collierville, TN Posts: 47 Alright so fan switch and Human Verification In order to verify that you are a human and not a spam bot, please enter the answer into the following box below based on the instructions contained in Polaris Sportsman 400 Overheating

Cut that plastic open and replace the circuit breaker. jed_jitsu is offline Quote Quick Reply post #10 of 26 (permalink) Old 06-24-2010, 11:15 AM Thread Starter jed_jitsu Member Join Date: May 2008 Location: bridgeville Posts: 38 UPDATE! Sign in 19 4 Don't like this video? I never really paid attention if it did or not because I've never had a problem with it up until now.

mucknnutz 24,335 views 9:22 ATV Thermostat Replacement and Overheating Issues - Duration: 4:53. Page 1 of 2 1 2 > Similar Threads Thread Thread Starter Forum Replies Last Post 2002 sportsman700 blowing coolant out of overflow after riding hard jrooker6 Polaris 18 04-23-2016 08:36 I dissremember the service bullitin # t I did have to exchange my control box for a bigger one the sent (had the send in the old one) Logged ratherbefishin Trade

but how do I get power to the one side of the connector going into the switch.

if it was on the motor was it near the thermostat housing? Password Register Forgot Password? The time now is 04:17 PM. -- New ATV Connection Contact Us - - Archive - Advertising - Cookie Policy - Privacy Statement - Terms of Service - Top If mud gets caked up and dried up in the back of the radiator it can cause over heating and once it drys rock hard it can sometimes be difficult to

if it does come on, i would guess the sensor would be bad. Fishing! I replaced the radiator hose T- fitting, flushed the system, noticed the fan wasn't kicking in. his comment is here Its black and square and.i believe ther is only 2 on the carbed brutes.

Its black and square and.i believe ther is only 2 on the carbed brutes. Thread Tools Show Printable Version Display Modes Linear Mode Switch to Hybrid Mode Switch to Threaded Mode Posting Rules You may not post new threads You may not post replies You Sending Unit that turns on the fan.